Con rod big end clearance specs?

Discuss all things 1970 & later Airheads right here.
Post Reply
DonW
Posts: 103
Joined: Fri Aug 06, 2010 4:25 pm
Location: NorCal- near Walnut Creek
Contact:

Con rod big end clearance specs?

Post by DonW »

Hi, I have now removed the con rods from my '92 GS engine. It looks like I'm not the first one (since the factory) to be in here. The con rods have professional looking markings for weight, and one has been shaved a bit. On my scale they weigh exactly the same - 678 grams- but borrowing a better scale this afternoon.

So, now I'm wondering if my lower end con rod bearings might be nearly new. I'm going to pick up some plasti-gage and measure. What I can't find in my Clymers or other stuff, is the tolerances for lower end clearance- anybody know?

Thanks,

Don
'83 R80ST
'92 R100GS
'04 R1150RTP
garage full of airhead parts...
DonW
Posts: 103
Joined: Fri Aug 06, 2010 4:25 pm
Location: NorCal- near Walnut Creek
Contact:

Re: Con rod big end clearance specs?

Post by DonW »

May have just found it on Duane's site- seem right?
Con. rod radial clearance 0.023-0.069mm (0.0009-0.0027")
'83 R80ST
'92 R100GS
'04 R1150RTP
garage full of airhead parts...
Kurt in S.A.
Posts: 1656
Joined: Tue Aug 03, 2010 12:08 pm

Re: Con rod big end clearance specs?

Post by Kurt in S.A. »

Those are the same numbers given in the Haynes manual.

Kurt in S.A.
DonW
Posts: 103
Joined: Fri Aug 06, 2010 4:25 pm
Location: NorCal- near Walnut Creek
Contact:

Re: Con rod big end clearance specs?

Post by DonW »

Wooo hoooo! Got a cool little scale at Harbor Freight (I think it's for weighing jewelery or drugs) that measure in grains and 1/10 grams. My rods are within 1/10 gram of each other, and my pistons are within 7/10s'. I ground a tad off the piston and it is now with in about 2/10's. Some PO had someone do a heck of a job balancing these things. Even are the same little end and big end on the con rods.

Plus, the "old bearings" read exactly the same as the new bearings. Bless those BMW lower ends!

Putting this thing back together!

Don
'83 R80ST
'92 R100GS
'04 R1150RTP
garage full of airhead parts...
Major Softie
Posts: 8900
Joined: Tue Aug 03, 2010 1:46 pm

Re: Con rod big end clearance specs?

Post by Major Softie »

Yeah, you either got VERY lucky, or (more likely) someone good has already been in there (which, I guess, is pretty lucky too).
MS - out
Post Reply